burning smell and oil on ground

[thatchrisguy]

Do u guys know where i can find a photo of a turbocharger? I've been looking on google with little success...

[Green1]

I typed turbo in to a google image search and found "about 35,200,000" results... the first one of which is:
http://volvospeed.com/Pics/Review/innovative_turbo.jpg

Another great page it came up with was: http://www.streetracersonline.com/articles/turbo/ which explains how a turbo works and has a cut-away view

[thatchrisguy]

well ya, but i meant on the delica and maybe attached so a dumbass like me can find it..

ok, i found one http://www.delica.ca/Photos/displayimag ... m=98&pos=8

[Green1]

basically, from under the vehicle follow the exhaust pipe back toward the engine, the first thing you get to that is bigger than the exhaust pipe is the turbo.

[Green1]

also, what you see in that picture is mainly the exhaust manifold, I think his thumbs are on the end of the turbo, but you can't really see it in that picture.

[thatchrisguy]

alright..i'll see if i can have a looksee tomorrow.. :)

[FalcoColumbarius]

Do u guys know where i can find a photo of a turbocharger? I've been looking on google with little success...

http://wikrad.com/delica/index.cgi?serv ... _downloads

Download " Delica_Engine_Manual.pdf (4D56 1991-1993) ". Section five has an exploded view of the turbocharger.

Falco.

[loki]

it's dry as can be under that access panel

IMG_0274 (Large).jpg

I see what looks like a hose missing though..but that's nothing.

I haven't looked at my van to compare because it's 12:35 am, but I think you might be missing something in the airbox, I didn't think you should be able to see the ground, I thought the airbox was sealed and has a one way valve to drain water out, I could be out to lunch though, up too late, need to sleep

[Green1]

I haven't looked at my van to compare because it's 12:35 am, but I think you might be missing something in the airbox, I didn't think you should be able to see the ground, I thought the airbox was sealed and has a one way valve to drain water out, I could be out to lunch though, up too late, need to sleep

You're out to lunch
The compartment isn't sealed, you're thinking of the air-filter housing, which has a drain valve on the bottom, not the whole compartment.

[loki]

I haven't looked at my van to compare because it's 12:35 am, but I think you might be missing something in the airbox, I didn't think you should be able to see the ground, I thought the airbox was sealed and has a one way valve to drain water out, I could be out to lunch though, up too late, need to sleep

You're out to lunch
The compartment isn't sealed, you're thinking of the air-filter housing, which has a drain valve on the bottom, not the whole compartment.

ah ok, thanks, silly me :)

[lrp374]

Chris if you want to see a picture the link in the Delica WIKI site shows the turbo @ the end of the Boost Rod.
http://wikrad.com/delica/index.cgi?boos ... adjustment
Larry

[thatchrisguy]

Hello again >> I haven't yet made it to Glenn's to have the Bichi looked at.
Now that it's dry out, I can see that the leaking diesel is showing up on the passenger side. I have to investigate further, but what would be a main cause??

[jessef]

See my original post below.

Common leaks

Injection pump
Halfmoon gasket seal

Could be a few things.

most common is the Injection Pump leaking because of the sulfur diesel here. Clean/Dry paper towel or rag and clean the under/sides of the IP until dry. Then start the Delica and run for a few mins. Run your finger around the sides and bottom to see if it's leaking. If it is, it's a rebuild. $$$

next is the halfmoon seal facing the rear (valve cover gasket). It's an inexpensive and easy fix. While doing that, look for pitting on the head and fill with silicone/gasket sealer if need be.

Or check the oil pump on the back of the alternator / the banjo bolt and the attached hoses/clamps. Either one may have come loose.

[thatchrisguy]

Yup...turns out it is the injector pump. It's gonna be costly, but i opted for the rebuilt, rather than a few seals replaced.. Hmmph.. oh well. She'll be better than new when done.. :)

I took 'er to Glenn in Coombs, so everything should be fab..

Chris

[FalcoColumbarius]

Do u guys know where i can find a photo of a turbocharger? I've been looking on google with little success...

It turns out that I had these in my celphone, they are not the best but you might find them useful as to how the turbo looks like on the engine:






Falco.